20 Common John Deere 1435 Problems And Troubleshooting

20 Common John Deere 1435 Problems and Troubleshooting

Introduction

The John Deere 1435 is a popular tractor that is used for a variety of tasks, including mowing, tilling, and plowing. However, like any piece of machinery, the 1435 can experience problems. This article will discuss 20 of the most common problems faced by 1435 owners, as well as provide troubleshooting tips for each issue. By understanding these common problems, you can be better prepared to maintain and operate your 1435 effectively.

Most Common Problems

The following are some of the most common problems reported by 1435 owners:

Engine problems: These can include problems starting the engine, loss of power, and overheating.
Transmission problems: These can include gear slipping, hard shifting, and transmission fluid leaks.
Hydraulic problems: These can include problems with the lift system, the steering, and the brakes.
Electrical problems: These can include problems with the lights, the gauges, and the starter.

What You Will Get in This Article

This article will provide you with the following information:

A list of the 20 most common problems faced by 1435 owners
Troubleshooting tips for each problem
Information on how to prevent problems from occurring
Resources for finding additional help and support

By reading this article, you will be able to better understand the common problems that can affect the 1435, and you will be better equipped to maintain and operate your tractor effectively.

20 Common John Deere 1435 Problems and Troubleshooting

Problem: Engine Won’t Start

Possible Causes

Dead battery
Faulty starter
Clogged fuel filter
Bad fuel pump
Faulty ignition switch
Bad spark plugs
Faulty fuel injectors
Blocked air filter
Low compression

Symptoms

The engine won’t turn over
The engine makes a clicking noise when you turn the key
The engine starts and then dies immediately
The engine runs rough
The engine loses power
The engine smokes

Recommended Solutions

Check the battery voltage with a voltmeter. If the battery is below 12 volts, it needs to be replaced.
Test the starter motor with a multimeter. If the starter motor is not getting power, check the wiring harness for damage.
Replace the fuel filter if it is clogged.
Test the fuel pump with a fuel pressure gauge. If the fuel pump is not producing enough pressure, it needs to be replaced.
Check the ignition switch for damage. If the ignition switch is faulty, it needs to be replaced.
Replace the spark plugs if they are damaged or worn out.
Clean or replace the fuel injectors if they are clogged.
Clean or replace the air filter if it is dirty.
Check the compression in the cylinders. If the compression is low, the engine needs to be rebuilt or replaced.

Problem: Engine Overheating

Possible Causes

Low coolant level
Faulty thermostat
Clogged radiator
Faulty water pump
Bad head gasket
Cracked engine block

Symptoms

The engine temperature gauge is high
The engine starts to overheat
The engine loses power
The engine makes a knocking noise
Steam coming from the engine

Recommended Solutions

Check the coolant level and add coolant if necessary.
Replace the thermostat if it is stuck open or closed.
Clean or replace the radiator if it is clogged.
Replace the water pump if it is faulty.
Repair or replace the head gasket if it is leaking.
Repair or replace the engine block if it is cracked.

Problem: Engine Misfiring

Possible Causes

Bad spark plugs
Faulty ignition coil
Clogged fuel injectors
Bad fuel pump
Faulty camshaft sensor
Faulty crankshaft sensor
Bad EGR valve
Bad MAP sensor
Bad TPS sensor

Symptoms

The engine runs rough
The engine hesitates when you accelerate
The engine stalls
The engine backfires
Black smoke coming from the exhaust

Recommended Solutions

Replace the spark plugs if they are damaged or worn out.
Replace the ignition coil if it is faulty.
Clean or replace the fuel injectors if they are clogged.
Replace the fuel pump if it is not producing enough pressure.
Replace the camshaft sensor if it is faulty.
Replace the crankshaft sensor if it is faulty.
Clean or replace the EGR valve if it is clogged.
Clean or replace the MAP sensor if it is faulty.
Clean or replace the TPS sensor if it is faulty.

Problem: Transmission Problems

Possible Causes

Low transmission fluid level
Faulty transmission fluid
Worn out transmission fluid
Faulty transmission solenoid
Faulty transmission shift linkage
Faulty transmission control module
Bad transmission bands
Bad transmission clutches
Worn out transmission gears

Symptoms

The transmission won’t shift gears
The transmission shifts hard
The transmission slips
The transmission makes a whining noise
The transmission makes a clunking noise
The transmission overheats

Recommended Solutions

Check the transmission fluid level and add fluid if necessary.
Replace the transmission fluid if it is old or contaminated.
Flush the transmission fluid if it is dirty.
Replace the transmission solenoid if it is faulty.
Adjust the transmission shift linkage if it is

Leave a Comment